OPTIONAL FILTER PRESS: ACID WASHING OF THE CLOTHES

Let’s analyse a further optional of the filter press: acid washing.

When the sludge to be filtered is very sticky or tends to encrust the filter cloths very quickly (causing problems relating to filtration pressure, filtration times, etc.), acid washing of the cloths is the device you were looking for.

WHICH ACID IS USED?

Usually, 3 to 5% diluted hydrochloric acid is used

 

HOW DOES THE ACID WASHING OF CLOTH WORK?

First of all, it should be pointed out, even if it may seem trivial and superfluous, that the acid washing of the cloth is performed when there is no sludge inside the volume of the machine. It is therefore an out-of-cycle phase and it is usually the user who decides (intervening from the HMI) after how many cycles or hours of use he wants to carry out the acid washing (based on the level of incrustations reached by the cloths).

This wash works by flooding; Once the moment has been decided in which to carry out the acid washing of the cloths, the machine will close the plate pack, through the hydraulic cylinder mounted in the rear fixed head, under pressure.
At this point, through special automatic valves usually placed in the line of the lower filtered discharge pipes, hydrochloric acid is introduced into the volume of the machine. Filling of the filter press ends when the acid starts to flow out of the upper filtered discharge manifolds. The filling signal of the machine can be obtained through a level probe or through a timer inside the PLC.

Now all the automatic valves remain closed allowing the acid to interact with the filter cloths, scraping them.
The acid is made to react with the cloths for a time that can be established and adjusted using the appropriate parameter in the HMI.
Once the end of the acid washing has been established, the acid discharge valve is opened and, by gravity, the acid flows out of the machine.
Depending on the type of process to be performed, the acid can be re-sent to the same tank from which it was taken, or sent to a second tank from which it will then have to be refined and reused.

WHAT DOES THIS DEVICE COMPOSED?

In the filter press, acid washing is basically accomplished by inserting a series of automatic valves:

Acid inlet valve

Acid outlet valve

Automatic shut-off valve/s; this

valve allows to divide the acid inlet circuit from the outlet one.

How. do I send the hydrochloric acid inside the filter press?

Yes, you can supply the hydrochloric acid pumping unit consisting of:

  • 3/5% acid tank
  • Pump

IF YOU DON'T HAVE 3%-5% HYDROCHLORIC ACID?

In the event that it is not possible to have hydrochloric acid at the right percentage (3/5%) but are concentrated HCl, it is possible to supply a sampling and dilution station which, by withdrawing from the concentrate tank, prepares the solution inside the tank described in the previous point.

CONTACT US